CNJ-016 Solution for injection Ref.[9912] Active ingredients: Vaccinia immunoglobulin

VIGIV is a solvent/detergent-treated, filtered sterile solution of purified gamma globulin (IgG) fraction of human plasma containing antibodies to vaccinia virus. It is stabilized with 10% maltose and 0.03% polysorbate 80 (pH is between 5.0 and 6.5) and contains no preservative. The product is a clear to opalescent liquid.

VIGIV is manufactured from plasma collected from healthy, screened donors with high titers of anti-vaccinia antibody (meeting minimum potency specifications) that is purified by an anion-exchange column chromatography method (3, 4). The plasma donors were boosted with vaccinia vaccine prior to donating plasma used in the production of the product. Each plasma donation used for the manufacture of VIGIV is tested for the presence of hepatitis B virus (HBV) surface antigen (HBsAg) and antibodies to human immunodeficiency viruses (HIV) ½ and hepatitis C virus (HCV) using FDA-licensed serological tests.

Plasma used in the manufacture of this product was tested by FDA licensed Nucleic Acid Testing (NAT) for HIV-1 and HCV and found to be negative. A NAT for HBV was also performed on all Source Plasma used and found to be negative; however, the significance of a negative result has not been established. The Source Plasma has also been tested by NAT for hepatitis A virus (HAV) and parvovirus B19 and the limit for B19 in the manufacturing pool is set not to exceed 10⁴ IU of B19 DNA per mL.

The manufacturing process contains two steps implemented specifically for virus clearance. The solvent and detergent step (using tri-n-butyl phosphate and Triton X-100) is effective in the inactivation of enveloped viruses, such as HBV, HCV and HIV (5). Virus filtration, using a Planova 20N virus filter, is effective for the removal of viruses based on their size, including some non-enveloped viruses (6). In addition to the two specific steps, the anion-exchange chromatography step contributes to the removal of small non-lipid enveloped viruses.

The inactivation and reduction of known enveloped and non–enveloped model viruses were validated in laboratory studies as summarized in Table 2.

Table 2. Virus Reduction Values (Log₁₀) Obtained through Validation Studies:

Abbreviations:

HIV-1: human immunodeficiency virus-1; relevant virus for human immunodeficiency virus-1 and model for HIV-2
BVDV: bovine viral diarrhea virus; model virus for hepatitis C virus (HCV) and West Nile virus (WNV)
PRV: pseudorabies virus; model for large enveloped DNA viruses, including herpes
HAV: human hepatitis A virus; relevant virus for HAV and model for small non-enveloped viruses in general
EMC: encephalomyocarditis virus; model for HAV and for small non-enveloped viruses in general
MMV: murine minute virus; model for human parvovirus B19 and for small non-enveloped viruses in general
PPV: porcine parvovirus; model for human parvovirus B19 and for small non-enveloped viruses in general
n.e.: not evaluated

^* The PRV was retained by the 0.1 μm pre-filter during the virus validation. Since manufacturing employs a 0.1 μm pre-filter before the 20N filter, the claim of ≥5.6 reduction is considered applicable.

The product potency (as determined by a plaque reduction neutralization test) is expressed in arbitrary units (U) by comparison to the FDA reference standard. Each vial contains approximately 40 to 80 mg/mL total protein and ≥50,000 units of vaccinia antibody neutralizing activity. The product contains ≤40 mcg/mL of Immune globulin A (IgA).